Service & Parts ManualConvotherm Combination Oven-Steamer MODELS: Gas 10.10 and 6.20OGB-10.10OGS-10.10OGB-6.20OGS-6.2007061333 East 179th St., Cl
1333 East 179th St., Cleveland, Ohio, U.S.A. 44110Ph: 1-216-481-4900 Fx: 1-216-481-3782 Web Site: www.clevelandrange.comCleveland Range, LLCS
NOTES:Cleveland Range reserves right of design improvement or modification, as warranted.Many regional, state and local codes exist and it is the resp
1333 East 179th St., Cleveland, Ohio, U.S.A. 44110Ph: 1-216-481-4900 Fx: 1-216-481-3782 Web Site: www.clevelandrange.comCleveland Range, LLCS
NOTES:Cleveland Range reserves right of design improvement or modification, as warranted.Many regional, state and local codes exist and it is the resp
1333 East 179th St., Cleveland, Ohio, U.S.A. 44110Ph: 1-216-481-4900 Fx: 1-216-481-3782 Web Site: www.clevelandrange.comCleveland Range, LLCS
NOTES:Cleveland Range reserves right of design improvement or modification, as warranted.Many regional, state and local codes exist and it is the resp
1333 East 179th St., Cleveland, Ohio, U.S.A. 44110Ph: 1-216-481-4900 Fx: 1-216-481-3782 Web Site: www.clevelandrange.comCleveland Range, LLCS
NOTES:Cleveland Range reserves right of design improvement or modification, as warranted.Many regional, state and local codes exist and it is the resp
Figure 4-1a Control Panel CONTROL PANEL BASIC OPERATION A. QUICK START GUIDE ALWAYS PRE-HEAT THE OVEN CHAMBER! 1. Switch on with key (1). 2. Se
Figure 4-1b Control Panel B. CONTROL PANEL DETAIL VIEW Note: Item numbers correspond to numbers on the control panels in Figure 4-1b 1. ON/OFF When
Table of ContentsInstallation For the Installer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1Warranty .
Function Indicators • Light up when function or activity is engaged: 10. Reduced Power 11. Burner or Electric Heating ON 12. Reduced Fan Speed 13. Coo
CAUTION Clean the oven chamber at least once per day or more frequently as needed Failure to clean the Combi properly and regularly can cause equipmen
CAUTION Do NOT use U-Shaped racks that are bent or otherwise damaged in any way. Pans and accessories placed in damaged racks can tip and spill, causi
Drain Cover and Drain e. Clean the Bypass Measuring Aperture. (Opening in the oven chamber on the left-hand side, slightly below the door latch. See
B. Semi-Automatic Cleaning of the Oven Chamber NOTE: Do NOT press the Start/Stop key while using the Semi-automatic Cleaning process. This stops the
a. The third step is Steam mode at 86°F for 1 minute. No action is needed. b. The fourth step is Steam at 212°F for 10 minutes, followed by a Signal
CAUTION Always make sure the cleaning agent containers are correctly connected to the Combi CONVOClean => RED CONVOCare => BLUE or WHITE C. CON
3 “Strong Soiling” 2 hours. 4 ‘Strong Soiling – Shining+” 2 hours and 45 minutes. 8. Press the Smart Key. 9. “Food inside oven?” appears in t
CAUTION Use ONLY the DISSOLVE® Descaler method using Part No. 106174 to descale the Combi. Read, understand, and follow both the descaling procedure i
WARNING This procedure is slightly different depending on the model being descaled. This entire procedure should be read and fully understand as it a
Table of Contents (continued)Service Parts Pump, Steam Generator, Gas, 110v (all models) . . . . . . . . . . . . . . . . . . . 54(continued) Burner I
• While adding liquid to the steam generator through the descaler inlets, pour slowly to avoid overflow. • Wipe up any spills at once to avoid etching
C3216313 B0706CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY OF CLEVE
C3216313 B0706IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115483 ASSEMBLY, PANEL, RIGHT SIDE, 10.10 2 1 C2114824 ASSEMBLY/WELDMENT,
C3216313 B0706CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY OF CLEVE
C3216313 B0706IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115483 ASSEMBLY, PANEL, RIGHT SIDE, 10.102 1 C2114824 ASSEMBLY/WELDMENT,
C3216313 B0706CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY O F CLEV
C3216313 B0706IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115482 ASSEMBLY, PANEL, RIGHT SIDE, 6.20 2 1 C2114826 ASSEMBLY/WELDMENT,
C3216313 B0706CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY OF CLEVE
C3216313 B0706IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2115482 ASSEMBLY, PANEL, RIGHT SIDE, 6.20 2 1 C2114826 ASSEMBLY/WELDMENT,
300480 C0706COMPONENT PANEL ASSEMBLY, GasOGB 6.20 & 10.10 MODELSCLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DES
NOTICEPost instructions to be followed if the user smells gas. Display the instructions in a prominent location. All users of this equipment must unde
300480 C0706COMPONENT PANEL ASSEMBLY, GASOGB 6.20 & 10.10 MODELSIITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 2 300419 TRANSFORMER,
300488 C0706COMPONENT PANEL ASSEMBLY, GASOGS 6.20 & 10.10 MODELSCLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DES
300488 C0706COMPONENT PANEL ASSEMBLY, GASOGS 6.20 & 10.10 MODELSIITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300419 TRANSFORMER,
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114297 WELDMENT, CONTROL PANEL2 1 C5019101 CONTROLLER, 5010 OPERATING MODULE3 1
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN32 1 C5016002 LOCKNUT M2531 1 C700106607000-1EDGE PROTECTOR, CUT 7.000"30 1 C70010
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114520 OUTER BASE, EL, 6.10/10.102 1 C2216088 AIR INLET BOX FINAL ASSEMBLY3 1 C
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114542 ASSEMBLY, OUTER BASE, GAS, STEAM GEN, 6.20/10.202 1 C2114699 ASSEMBLY, TOP
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114542 ASSEMBLY, OUTER BASE, GAS, STEAM GEN, 6.20/10.202 1 C2016147 CONDENSER HOS
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2114522 ASSEMBLY, OUTER PLATE EL 6.20/10.202 1 C2114699 ASSEMBLY, TOP COVER, PUMP
Cleveland STATEMENT OF POLICIES L I M I T E D W A R R A N T Y CLEVELAND RANGE products are warranted to the original purchaser to be free from defec
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C6015215 ELBOW, HOSE CONNECTION, 3/8" WITH SEAL2 2 111647 CLAMP, OETIKER, S/S,
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 3 300407 FILTER, ELECTRICAL2 6 300509 TERMINAL, 18-22 AWG PIGGY BACK3 4 111498 HOSE,
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 3 300407 FILTER, ELECTRICAL2 6 300509 TERMINAL, 18-22 AWG PIGGY BACK3 4 111498 HOSE,
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300456 VALVE ASSY. 2 WAY 120VAC 2 4 111498 HOSE, SILICONE, 3/8" ID (SPECIFY LEN
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300453 VALVE ASSEMBLY, 3WAY 240VAC300363 TRIPLE SOLENOID VALVE 110-120V 50/60 Hz 180º
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300456 VALVE ASSY. 2 WAY 120VAC2 2 111498 HOSE, SILICONE, 3/8" ID (SPECIFY LEN
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 300363 TRIPLE SOLENOID VALVE 110-120V 50/60 Hz 180º (OGS 6.20)2 3 300407 FILTER, ELECT
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2314891 WELDMENT, GEN GAS 6.20 (NOT SHOWN)2 1 C2314243 SUPPORT, STEAM GEN, TABLE T
CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574THIS DESIGN DESCRIBES A PROPRIETARY ITEM AND IS THE PROPERTY OF CLEVELAND RANGE.THI
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2010045 BURNER INSERT GEN STEAM 6.10/6.20/10.10 WELDED2 1 C6015032 SEAL, BURNER ø
GENERAL INFORMATION ABOUT COMBIS A. PRODUCT INFORMATION Cleveland Range, LLC assigns two product identification numbers to each Combi: a model numb
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2010050 BURNER INSERT HL, 6.10/6.20, WELDMENT1 C2010052 BURNER INSERT, HL, 10.10/20.1
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2616521 BURNER INSERT, HL, PRE-MOUNTED, 6.10/6.201 C2616522 BURNER INSERT, HL, PRE-AS
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2514358 ASSEMBLY, OUTER DOOR, 6.201 C2514359 ASSEMBLY, OUTER DOOR, 10.102 1 C2514
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2614806 CARRIAGE PLATE, WELDED, 6.20C2614807 CARRIAGE PLATE, WELDED, 10.10 & 10.
AEDDEBCINSTALLEDORIENTATIONSECTION E-EDETAIL CDETAIL B DETAIL ASECTION D-D4119 20 81472113 214216182011 211017172214 213 961558 14418C2614801 B, C2614
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C2514351 DOOR, 6.20, COMPLETE- 1 C2514352 DOOR, 10.10, COMPLETE2 1 C2114652 WELDMENT, COR
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C3216201 WELDMENT, STAND, COMBI, 6.10/10.102 2 100413 FOOT ASS'Y, ADJUSTABLE (
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1 1 C3416377 WELDMENT, BASE, STACKING KIT, GAS, 6.20/10.202 1 C3416369 WELDMENT, EXHAUS
IITTEEMM QQTTYY PPAARRTT NN00.. DDEESSCCRRIIPPTTIIOONN1* 1 C3416368 WELDMENT, BASE, STACKING KIT, ELECTRIC, 6.10/10.102* 1 C3416362 SHROUD, S
CLEVELAND RANGE OGB 6.20/10.10SEQUENCE OF OPERATIONSWhen using these instructions refer to the OGB 6.20/10.10 wiring schematic.1 When 120 VAC is appl
INSTALLATION INSTRUCTIONS A. GENERAL This equipment should be installed only by qualified, professional plumbers, pipe fitters, and electricians.
• 120 VAC is sent from terminal 1 of connector X13 on the Control Board(A10) to the Generator Pump (M4).• As the water level drops below the probes
a The front display will include a lighted bar under the steam symbol• When the heat circuit is energized the heat symbol will be energized• The co
5 With the combi in the Hot Air mode with time on the timer, the door closed and thestart switch is depressedb The front display will include a ligh
f The heat circuit will remain energized until the cabinet set temperature is reachedg When the condensate box is heated to 140 degrees F at the B3p
◊ When this speed is attained the signal is sent from terminal 2 of connectorX2 on the Steam Power Burner and Fan Control (U21) to terminal 9 ofconne
◊ In the full mode (3 drops in the display) the Y2 valve will be energizedcontinuously.h When the timer counts to 0 or the core temp probe (B10) rea
• A signal is sent from terminal 2 of connector X24 on the Gas Board (A20) toterminal 4 of connector X2 on the Hot Air Power Burner and Fan Control(U
CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN BYDRAWING NO.THIS DESIGN DE
-M1M 3~W2/YEU1/BKGND20-X10POWER SUPPLY 12VDC96-264VAC12V DC1L1GNDFAN23NBK 12BU 1230-X10BK 12-F1.12A12-X1031RD 18LNRD 18-A10:X12:1/3.D60V12VBU 18BU 18R
MMSM 5010-M3.1-Y1-F2.1-A10-X10-M4-X10-S7-S2-X10-Y10-Y20-Y22-Y23/2.E3-G1:12V/2.E3-G1:0V/2.C4-X10:31123456789101112 1234567812345671141312 11 10 57986 3
B. INSTALLATION OF THE COMBI – General Instructions General Instructions: 1. Select the Combi’s operating location. 2. Complete the water, drain,
123456789101112X27:X26: X25: X24: X23:876543217845623178456231 465 13212 10 9111112 91049865713218234 765910219543678985764321X22:X28:-X10X21:42 43414
RD 18RD 18RD 18RD 18RD 18RD 18BU 18BU 18BU 18RD 18BU 18RD 18GN 18RD 18BU 18/6.A1/3.F8-X1023/3.D5-X10:32/6.A4-X10:34-X1033GN 18-U20BURNER FAN (HOT AIR)
-X10/4.E6-X1011-X10:33RD 16RD 16HOT SURFACE IGNITION (STEAM GEN)STEAM GENERATOR BURNER CONTROLBU 18RD 18BU 18RD 18-R212 1FLAME SENSOR-P2-N213123RD
24 VAC120VAC -T124 VACTRANSFORMERTRANSFORMER120VAC -T2RECIEVETRANSMIT12VGND-A20:X261342MOTOR DRIVE2ARD-Z1L1NLINE FILTERNL1FANGNDRxD12VCOMTxDV2/WHW2/YE
HOT SURFACE 12-P1FLAME SENSOR -R2012SPEED STEAM GENERATORGROUND STEAM GENERATORGAS BOARDX2:GROUND HOT AIR 1POWER BURNER HOT AIR FAN CONTROL -
DOOR MAGNET SWITCH14X14:21756431089PUMP / CLEAN AGENTCOMPARTMENT RINSE V.STEAM GEN OVER TEMPX15:1234BUWATER LEVEL PROBEH-B1LRD5786910111213-S213-S71
CLEVELAND RANGE OGS 6.20/10.10SEQUENCE OF OPERATIONSWhen using these instructions refer to the OGS 6.20/10.10 wiring schematic.1 When 120 VAC is appl
• When the heat circuit is energized the heat symbol will be energized• The cooking mode symbol will be energized.• The time display will invert an
a The front display will include a lighted bar under the Hot Air symbol• When the heat circuit is energized the heat symbol will be energized• The
e When the timer counts to 0 or the core temp probe (B10) reaches the set amountthe cycle .5 With the combi in the Combi mode with time on the timer
C. SPECIAL INSTRUCTIONS FOR CASTER EQUIPPED COMBI STANDS AND COMBIS 1. Read all instructions before beginning installation. 2. Level the floor if
e When the condensate box is heated to 140 degrees F at the B3probe, 120 VAC issent from terminal 5 of connector X12 to the condenser valve (Y1) unti
◊ The Hot Air Burner Control Module (N20) senses at least 1.5 micro ampsDC from the flame sensor (P1) at terminal 3 of connector X2 and sends asignal
CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN BYDRAWING NO.THIS DESIGN DE
-M1M 3~W2/YEU1/BKGND20-X10POWER SUPPLY 12VDC96-264VAC12V DC1L1GNDFAN23NBK 12BU 1230-X10BK 12-F1.12A12-X1031RD 18LNRD 18-A10:X12:1/3.D60V12VBU 18RD 18R
MSM 5010-M3.1-Y1-F2.1-A10-X10-X10-S7-S2-X10-Y10-Y20-Y22-Y23/2.E3-G1:12V/2.E3-G1:0V/2.C4-X10:31123456789101112 1234567812345671141312 11 10 57986 34211
RD 18RD 18RD 18RD 18RD 18RD 18BU 18BU 18BU 18RD 18BU 18RD 18GN 18RD 18BU 18/3.F8-X1023/3.D6-A10:X11:8-X1033GN 18-U20BURNER FAN (HOT AIR)X1:X2:X3:X1:X2
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
FEDCBA12345678FEDCBA12345678CLEVELAND RANGE, LLC1333 East 179th St., Cleveland, Ohio 44110-2574VOLTAGE: WATTAGE: CURRENT: DATESHEET OF REVDRAWN
Commentaires sur ces manuels