Part No. COMBI-OE-INM REV. A, 8/05 Installation Manual Installation and Maintenance Instructions CONVOTHERM BY CLEVELAND COMBI ELECTRIC MODELS
4 D. Control Panel ON/OFF (1) • When Combi is turned ON: • Self-diagnosis is performed. • Oven light comes on. • Steam generator fills and
5 Function and Operation Icons (10-16) • Icons light when function or activity is engaged: Reduced Power (10) (optional feature for ELECTRIC mode
6 CHAPTER 2 INSTALLATION INSTRUCTIONS A. GENERAL This equipment should be installed only by qualified, professional plumbers, pipe fitters, and el
7 B. INSTALLATION OF THE COMBI – Overview and General Instructions 1. Select the Combi’s operating location. 2. Complete the drain, el
8 C. INSTALLATION OF THE COMBI 1. Selecting a Location for the Combi a. For safe and efficient operation, observe the following criteria when s
9 D. UTILITIES CONNECTIONS FOR THE INSTALLATION OF THE COMBI 1. Install Electric Power Lines The electrical supply must match all electrical and
10 2. Electrical Connection Data Minimum wire gauge required for field connection Attention: alwa
11 3. Install Water Supply a. Install the water supply before positioning the Combi. b. Water supply line(s) must be designed so the Combi can be
12 2) Water Supply System Pressure Requirements The water supply must provide: • A minimum dynamic pressure of 35 psi (2.4 kg/cm2) • A maximum s
13 Figure 2-10 Cleveland Range Single Water Supply Arrangement Figure 2-11 Cleveland Range Separate Water Supply Arrangement * “Conditi
FOR THE INSTALLER ALL SERVICE MUST BE PERFORMED BY A QUALIFIED CLEVELAND RANGE AUTHORIZED TECHNICIAN. This Installation Man
14 4. Install Free Air Vented Drain Lines Furnishing and installing drain lines is the responsibility of the Owner/Installer. a. The
15 Figure 2-12 Typical Drain Layout Figure 2-12 A NUMBER, DESCRIPTION, AND PART NUMBER 1 GASKET, INTERNAL, DRAIN T
16 5. Exhaust Hood Requirements a. Installation under an exhaust hood may be required. Check local requirements before installing a Combi or any o
17 6. Moving a Combi to its Operating Location a. Transport the Combi on a pallet. b. Keep the Combi UPRIGHT. c. The packing list is under the t
18 7. For ALL Combis a. Keep the vents on the bottom and top of the Combi clear, clean, and free of obstruction. b. The floor where the
19 Figure 6 Figure 4 7 Figure 5
20 9. CHECKOUT and STARTUP The Checkout and Startup procedure prepares a recently installed or repaired Combi for operation. The procedures check
21 DANGER Do NOT attempt to operate a Combi during a power failure! In the event of a power failure: turn OFF the Main External Power Switch and
22 A. STARTUP PROCEDURE Note: If the Combi has been delivered when the outside temperature is below 40° F then wait for the Combi to warm up to roo
23 7. SET CONTROL PANEL OPTIONS. a. Start Setup Procedure 1) Press Smart Key . 2) Use the Selector Dial 6019002_00D to select Setup . 3) Confirm:
Cleveland STATEMENT OF POLICIES L I M I T E D W A R R A N T Y CLEVELAND RANGE products are warranted to the original purchaser to be free from def
24 f. Set Date 1) Start Setup Procedure (Above). 2) Select Date with the Selector Dial 6019002_00D. 3) Confirm with Smart Key . 4) Select date f
25 d) Confirm by pressing Smart Key . e) Confirm “Yes” with Smart Key . f) The Program Protection icon appears. g) The display shows the nomin
26 i. Press Smart Key to start the cleaning cycle. j. Step 1 of 4 is Hot Air at 158°F (70°C) for 10 minutes. k. Signal Tone sounds and display
27 5. TEST Temperature Probe: a. Remove plastic tip protector from probe. b. Replace probe in its hanger. c. Set Temperature to 350° F in any c
28 CHAPTER 4 TROUBLESHOOTING Convotherm by Cleveland Combi Oven-Steamers are equipped with an automatic error diagnosis system. If an error occurs
29 Error Messages and Remedies Error Message on display Possible cause Remedy Water tap closed Open water tap Solenoid valve dirt filter clogge
30 These operating irregularities do not have error messages. Error Possible cause Remedy Suction plate not correctly locked Lock suction plate cor
31 CHAPTER 5 Emergency Operation To continue to use your Convotherm by Cleveland Combi Oven-Steamer in the case of an error, which cannot be solve
32 The Combi will operate if these errors occur X: Operation possible –: Operation not possible 1) Cooking time will be much longer, dishes in uppe
33 E26 Steam generator safety temp. limiter sensor failure X X X X X X X X X X E23& E26(3) Steam generator safety temp. limiter and steam
Free Start-Up Program Get the most from your Cleveland Range equipment with Cleveland Range’s “Free Start-Up.” Performance Check-Out: Contact your
Chapter INSTALLATION AND MAINTENANCE Table of Contents Page 1 GENERAL INFORMATION ABOUT CONVOTHERM BY CLEVELAND 1 GENERAL SAFETY GUIDELINES F
1 CHAPTER 1 GENERAL INFORMATION ABOUT CONVOTHERM BY CLEVELAND A. GENERAL SAFETY GUIDELINES FOR INSTALLERS, USERS, AND SERVICE TECHNICIANS 1. Re
2 B. PRODUCT INFORMATION Cleveland Range, LLC assigns two product identification numbers to each Combi: a model number and a serial number. The mode
3 C. PRODUCT VIEWS Figures 1-2 and 1-3 1. Control Panel 2. Disappearing Door with Double Glass Panel 3. Door Handle • Vertical: closed. • Horizonta
Commentaires sur ces manuels